ULINE Anti Fatigue Mat Instructions
INSTRUCTION
INITIAL MAT USE AND STORAGE
- Unroll mat within a few days of receipt. Let mat lay Sat for 24 hours at room temperature before placing out for use. If the mat will not lay flat, move to a warm area. Heat will cause the vinyl mat to become more pliable and lay flat more quickly.
- To store mat, roll it up and lay on its side in a moderate temperature, dry area. Do not stand on edge or crush.
SPECIFICATIONS
Acceptable usage is determined by resistance as listed in the table below.
Unacceptable usage leads to product failure and voids warranty. These ratings are to be used as a guide only. Actual results may vary depending on concentration of chemicals. Ratings for vinyl products performed at 68°F.
RESISTANCE LEGEND:
1 = Recommended
2 = Suitable for Use
3 = Usable, Not Recommended
| CHEMICAL | FORM | CHEMICAL FAMILY | CONCENTRATION | RESISTANCE |
2-Propanol (isopropyl alcohol) | Liquid | Alcohol | 2 | |
Acetaldehyde | Liquid | Aldehyde | 50% | 3 |
Acetic Acid | Liquid | Acid (weak, organic) | 50% | 2 |
Acetone | Liquid | Ketone | 3 | |
Ammonium Hydroxide | Liquid | Base (weak) | 28-30% | 1 |
Amyl Acetate | Liquid | Carboxylic Acid (Aliphatic) | 3 | |
Beef Fat | Solid/Liquid | 2 | ||
Benzoic Acid | Liquid | Carboxylic Acid (Aromatic) | 1 | |
Boric Acid | Liquid | Acid (weak) | 1 | |
Bromine | Liquid/Gas | Halogen | 2 | |
Butane | Liquid | Aliphatic HC | 3 | |
Butter | Solid/Liquid | 1 | ||
Butyl Acetate | Liquid | Carboxylic Acid (Aliphatic) | 3 | |
Butyl Alcohol (butanol) | Liqud | Alcohol | 1 | |
Calcium Chloride | Solid | Inorganic Salt | 2 | |
Calcium Hydroxide | Solid | Metal Hydroxide | 2 | |
| Carbon Monoxide | Gas | Inorganic Carbon Compound | 1 | |
Chicken Fat | Solid/Liquid | 2 | ||
Chromic Acid | Liquid | Acid (weak) | 50% | 3 |
| Citric Acid | Liquid | Acid (weak, organic) | 10% | 2 |
Corn Oil | Liquid | Fatty Acid | 1 | |
| Cottonseed Oil | Liquid | Aliphatic HC | 1 |
CHEMICAL | FORM | CHEMICAL FAMILY | CONCENTRATION | RESISTANCE |
Cyclohexanol | Liquid | Alcohol (cyclic) | 1 | |
| Dibutyl Phthalate | Liquid | Ester | 3 | |
Diesel Fuel | Liquid | Petroleum HC | 3 | |
| Diesel Oil | Liquid | Petroleum HC | 3 | |
Ethane | Liquid | Aliphatic HC | 1 | |
| Ethyl Acetate | Liquid | Ester | 3 | |
Ethyl Alcohol (ethanol) | Liquid | Alcohol | 3 | |
| Ethyl Ether | Liquid | Ether | 3 | |
Ethylene Glycol (antifreeze) | Liquid | Alcohol | 1 | |
| Formaldehyde | Liquid | Aldehyde | 37% | 1 |
Formic Acid | Liquid | Acid (weak, organic) | 1 | |
| Fresh Water | Liquid | 1 | ||
Fuel Oil | Liquid | Aliphatic HC | 2 | |
| Gasoline | Liquid | Aliphatic HC | 3 | |
Gear Oil (85w-140) | Liquid | Paraffin Oil | 2 | |
| Glucose | Liquid | Sugar | 1 | |
Glycerin | Liquid | Alcohol | 1 | |
| Heptane | Liquid | Aliphatic HC | 2 | |
Hexane | Liquid | Aliphatic HC | 3 | |
| Hydraulic Fluid | Liquid | Aliphatic HC | 2 | |
Hydrazine | Liquid | Base (weak) | 1 | |
Hydrochloric Acid | Liquid | Acid (strong) | 30% | 2 |
| Hydrofluoric Acid | Liquid | Acid (weak) | 30% | 3 |
Hydrogen Peroxide | Liquid | 1 | ||
Iodine | Liquid | Inorganic Halogenated Comp | 1 | |
Jet Fuel | Liquid | Aromatic HC | 3 | |
Kerosene | Liquid | Aliphatic HC | 3 | |
Linseed Oil | Liquid | Fatty Acid | 2 | |
Methane | Liquid | Aliphatic HC | 2 | |
Methyl Alcohol (methanol) | Liquid | Alcohol | 1 | |
Methyl Formate | Liquid | Alcohol | 3 | |
Methyl Methacrylate | Liquid | Ester | 1 | |
Mineral Oil | Liquid | Petroleum HC | 3 | |
Mineral Spirits | Liquid | Aliphatic HC | 3 | |
Motor Oil 10w-30 (natural) | Liquid | Paraffin Oil | 2 | |
Motor Oil 10w-30 (synthetic) | Liquid | Paraffin Oil | 2 | |
Naptha | Liquid | Aromatic HC | 2 | |
Nitric Acid | Liquid | Acid (strong) | 20% | 2 |
Nitric Acid | Liquid | Concentrated | 2 | |
Octane | Liquid | Aliphatic HC | 2 | |
Oleic Acid | Liquid | Acid | 3 | |
Oxalic Acid | Liquid | Acid (weak) | 2 |
CHEMICAL | FORM | CHEMICAL FAMILY | CONCENTRATION | RESISTANCE |
Peanut Oil | Liquid | Fatty Acid | 1 | |
| Pentane | Liquid | Aliphatic HC | 2 | |
| Perchloroethylene | Liquid | Aliphatic HC (chlorinated) | 3 | |
| Petroleum | Liquid | Aliphatic HC | 2 | |
Phosphoric Acid | Liquid | Acid (weak) | 1 | |
| Pine Oil | Liquid | 20%=Pine-Sol | 3 | |
Potassium Hydroxide | Liquid | Base (strong) | 50% | 1 |
| Power Steering Fluid | Liquid | Napathenic Oil | 2 | |
Propane | Liquid | Aliphatic HC | 1 | |
| Propyl Alcohol (propanol) | Liquid | Alcohol | 2 | |
Salt Water | Liquid | 1 | ||
| Silicates | Solid | Alkali Metals | 1 | |
Silver Nitrate | Solid | Inorganic Salt | 1 | |
| Sodium Bicarbonate | Solid | Inorganic Salt | 1 | |
Sodium Hydroxide | Liquid | Base (strong) | 2 | |
| Sodium Hydroxide | Liquid | 0.34% = Mr. Clean | 1 | |
Sodium Hypochlorite (bleach) | Liquid | Base | 1 | |
| Stearic Acid | Liquid | Fatty Acid | 2 | |
Sulfuric Acid | Liquid | Acid (strong) | <10% | 1 |
| Sulfuric Acid | Liquid | 10-75% | 1 | |
| Transmission Fluid | Liquid | Napatheic or Paraffin Oil | 2 | |
Vegetable Oil | Liquid | Aliphatic HC | 1 | |
| Vinegar | Liquid | Acid (weak, organic) | 5% Acetic Acid | 1 |
MAINTENANCE
Regular maintenance of your mat is critical to extend mat life and appearance. It is recommended that a regular maintenance schedule be developed. Frequency will depend on traffic and soil conditions. Improper use or lack of maintenance will void mat or matting warranty.
PERIODIC INSPECTION
Periodic inspection is recommended to check for tears on a regular basis. To repair a damaged area, glue the section together with cyanoacrylate ester type (super glue) adhesive such as Uline S 17190 Loafer,’ Instant Adhesive.
GENERAL MAINTENANCE
If used in a dry environment sweep regularly or dry mop the surface. These mats can be damp mopped with a mild soap or detergent.
1-800-295-5510
WEB: uline.com
